An Effective Treatment to Reduce Escherichia coli O157:H7 and Salmonella on Alfalfa Seeds
Tong Zhao*, Ping Zhao, and Michael P. Doyle, Center for Food Safety,
Abstract
Since 1994, raw sprouts have been implicated as vehicles of outbreaks of E. coli
O157:H7 and Salmonella both nationally and internationally. Most outbreaks were associated with alfalfa sprouts, but cress, mung bean, and clover sprouts have been implicated. Many treatments, including heat and chemicals [NaOCl, Ca(OCl)2, acidified NaCIO2, acidified CIO2,
Na3PO4, Vegi-Clean, Tsunami, Vortexx, and H2O2] have been evaluated for their ability to reduce
E. coli O157:H7 contamination on alfalfa seeds, but none can definitely eliminate the pathogen and render seeds with acceptable germination rates. The purpose of our study was to determine the best concentrations and exposure time of a levulinic acid plus sodium dodecyl sulfate (SDS) treatment to reduce E. coli O157:H7 and Salmonella populations on alfalfa seeds and yield viable seeds with acceptable germination rates. A 5-strain mixture of E. coli O157:H7 or S. Typhimurium at 108 CFU/g was inoculated on alfalfa seeds. The seeds were dried at 21°C for up to 72 h. A 0.5% levulinic acid and 0.05% SDS treatment for 5 min at 21°C reduced E. coli O157:H7 and S. Typhimurium populations to undetectable levels (<5 CFU/g), however, some treated seeds were pathogen-positive by selective enrichment culture.
Introduction
A large multicountry outbreak of salmonellosis associated with alfalfa sprout occurred in
Sweden and Finland in 1994, with almost 500 cases reported. S. Bovismorbificans was the causative agent and was traced to Australian alfalfa seeds that were treated with a solution of 0.5% NaOCl for 45 min prior to sprouting. A year later, three alfalfa sprout-associated outbreaks caused by Salmonella of different serotypes occurred in the US, with some also involving Finland and Canada. Since then there have been many more outbreaks of salmonellosis and E. coli O157:H7 infections associated with alfalfa sprout consumption. We have developed an antimicrobial treatment composed of levulinic acid plus SDS that effectively kills Salmonella and E. coli O157:H7 on foods and in treatment solutions, and does not adversely affect the sensory characteristics of the treated food. The purpose of our study was to determine the best concentration and exposure time of this chemical treatment to kill Salmonella and E. coli O157:H7 on alfalfa seeds and yield seeds with acceptable germination rates.
Materials and Methods Bacterial strains. To facilitate enumeration of E. coli O157:H7, nalidixic acid-resistant (50 µg/ml) strains were used. Five isolates of Escherichia coli O157:H7, including 932 (human isolate), E009 (beef isolate), E0018 (cattle isolate), E0122 (cattle isolate), E0139 (deer jerky isolate) or five isolates of Salmonella Typhmurium DT104, including H2662 (cattle isolate), 11942A (cattle isolate), 13068A (cattle isolate), 152N17-1 (dairy isolate) and H3279 (human isolate) were used as 5-strain composite mixtures. Chemicals and chemical treatments. Levulinic acid at 0.5% and 0.05% sodium dodecyl sulfate (SDS) were tested in combination at 21 ± 2°C as a wash treatment for their killing effect on E. coli O157:H7 and S. Typhimurium on alfalfa seeds. Calcium hypochlorite [20,000 µg/ml (ppm)] was used as a positive control and deionized water was used as a negative control. Water.Deionized, unchlorinated water (filter sterilized through a 0.2-µm regenerated cellulose filter), tap water and autoclaved tap water were used. Inoculation of alfalfa seeds. Alfalfa seeds were obtained from Caudill Seeds Co., Louisville, Ky., and had a germination rate of approximately 91%. Dry seeds (50 g) were placed in a sterilized glass beaker (1 L) and 5 ml of a 5-strain mixture of E. coli O157:H7 or S. Typhimurium DT 104 (108-109 CFU/ml or 103-104 CFU/ml) was inoculated on the surface of the seeds then dried in a laminar flow hood for 1, 4, 24, 48, and 72 h. Determination of Salmonella and E. coli O157:H7 inactivation on alfalfa seeds. Inoculated and dried alfalfa seeds (50-g samples) were placed in a 1000-ml glass beakers containing 200 ml of levulinic acid plus SDS or controls and agitated at 150 rpm with a magnetic stir bar at 21°C for 0, 1, 2, 5, 10, 20, 30 and 60 min. Following treatment, the sample (1 or 25/g or ml) was placed in a stomacher bag containing 9 ml or 25 ml of 0.1 M phosphate buffer, pH 7.2 (PBS), or neutralizing buffer and pummeled for 1 minute at 150 rpm in a stomacher blender. The suspension was serially (1:10) diluted in 0.1% peptone water and 0.1 ml of each dilution was surface-plated in duplicate onto plates of TSA and Sorbitol MacConkey agar each containing 50 µg nalidixic acid/ml (TSA-NA and SMA-NA) for E. coli O157:H7; and TSA and XLD containing ampicillin (32 µg/ml), tetracycline (16 µg/ml) and streptomycin (64 µg/ml) (TSA+ and XLD+) for S.
Typhimurium DT 104. All plates were incubated at 37°C for 48 h.
Determination of seed germination percentage. To determine the germination percentage, treated and control seeds (5 gram per replicate) were placed on the surface of a plastic tray. A second tray containing 200 ml of sterile deionized water was placed with tray with seeds and water dropped into lower tray to maintain uniform moisture. The seeds were incubated at approximately 22°C for 72 h. Results and Discussions
Results revealed that a viable population of 108 CFU E. coli O157:H7/g of alfalfa seeds
was present after drying for 4 h (Table 1). Treatments with 20,000 ppm calcium hypochlorite or 0.5% levulinic acid plus 0.05% SDS for up to 60 min reduced the E. coli O157:H7 population by greater than 6 and 5 log CFU/g, respectively.
The population of E. coli O157:H7 was reduced byt 3 log CFU/g after drying for 24 h.
Treatment with calcium hypochlorite and 0.5% levulinic acid plus 0.05% SDS for 5 min reduced E. coli O157:H7 populations to levels only detectable by enrichment culture. Similar results were observed with seeds dried for 48 and 72 h (Table 1).
Results revealed that a viable population of 106 to 107 CFU S. Typhimurium DT 104/g
of alfalfa seeds was present after drying for 4 h. Treatments with 20,000 ppm calcium hypochlorite or 0.5% levulinic acid plus 0.05% SDS provided similar results, inactivating all Salmonella, including by enrichment culture, within 5 min (Table 2).
Drying seeds for 24, 48, or 72 h reduced the population of Salmonella by ca. 4 log CFU/
g. Treatment with 20,000 ppm calcium hypochlorite or 0.5% levulinic acid plus 0.05% SDS for 5 min reduced Salmonella to levels undetectable by direct plating, but still detectable by enrichment culture (Table 2).
Both chemical treatment solutions were negative for E. coli O157:H7 or Salmonella
following treatment of contaminated seeds. Seeds treated for 10 min were transferred to a stomacher bag and pummeled for another 10 min at 200 rpm. Results revealed that all five samples treated with 20,000 ppm calcium hypochlorite or 0.5% levulinic acid and 0.05% SDS were E. coli O157:H7- and Salmonella-negative by direct plating, only (two of ten samples) treated with 0.5% levulinic acid and 0.05% SDS were negative by enrichment culture.
The germination rate of alfalfa seed treated with 0.5% levulinic acid plus 0.05% SDS for
1 h at 21°C was 80%, with tap water was 71%, and for 20,000 ppm caicium hypochlorite was 47.3%.
Conclusion
Similar results of E. coli O157:H7 and Salmonella inactivation on alfalfa seeds
were obtained with treatments of 20,000 ppm calcium hypochlorite, pH 11.4, or 0.5% levulinic acid plus 0.05% SDS, pH 3.2. Alfalfa seed germination percentages were substantially greater when treated with levulinic acid plus SDS than calcium hypochlorite.
Acknowledgment
This study was funded by a grant from Caudill Seeds Co.
Table 1. E. coli O157:H7 counts on alfalfa seeds with an initial inoculum of 108 CFU/g and dried at 21°C in a laminar hood for different times
E. coli O157:H7 counts (CFU/g) on seeds dried for 4 h and treated for minutes:
E. coli O157:H7 counts (CFU/g) on seeds dried for 24 h
E. coli O157:H7 counts (CFU/g) on seeds dried for 48 h
E. coli O157:H7 counts (CFU/g) on seeds dried for 72 h
A: 0.1 M PBS, pH 7.2; B: 20,000 ppm Ca(OCl)2, pH 11.4; C: 0.5% levulinic acid + 0.05% SDS, pH 3.2
Table 2. S. Typhimurium DT 104 counts on alfalfa seeds with an initial inoculum of 108 CFU/g and dried at 21°C in a laminar hood for different times
S. Typhimurium DT 104 counts (CFU/g) on seeds dried for 4 h and treated for minutes:
S. Typhimurium DT 104 counts (CFU/g) on seeds dried for 24 h
S. Typhimurium DT 104 counts (CFU/g) on seeds dried for 48 h
S. Typhimurium DT 104 counts (CFU/g) on seeds dried for 72 h
A: 0.1 M PBS, pH 7.2; B: 20,000 ppm Ca(OCl)2, pH 11.4; C: 0.5% levulinic acid + 0.05% SDS, pH 3.2
New Network Addresses Gender Pay Equality Questions Published in Network, newsletter of the British Sociological AssociationNumber 89, Autumn 2004Why are changes in gender inequalities so much faster and more consistentin some spheres and social groups than in others? Why are new payinequalities between women emerging and growing? Why, despite the manypolicy initiatives concerned with addressi
Guidelines: Diabetes Nurse Educator Intake Priority Tool PRIORITY 1 CLIENTS: Priority 1 clients will preferably be contacted by a Diabetes Nurse Educator within 24 hours. If this is not possible the client will be contacted by a Community Health Nurse or other clinical health professional within 24 hours. Initial assessment will be undertaken by phone or face to face at the